Now that the Dash Assembly is out of this 2007 Town Car it is time to start changing actuators. The image below is of the backside of the dash assembly. In the very center of the picture is the mode housing. If you look to the right edge you should notice a white round piece … Continue reading “2007 Lincoln Town Car HVAC Actuator Replacement”
Now that the Steering Column has been removed and Part One of The Dash Removal has been completed the focus can be turned to the lower connection points. The rocker/kick panel trim cover can be removed by lifting the inner rear edge and shown below. This will release the spring clips that hold it to … Continue reading “2007 Lincoln Town Car Dash Removal Part 2”
Time to remove the dash assembly from this 2007 Lincoln Town Car. I had previously diagnosed a faulty Panel/Defrost Mode Actuator and removed the Steering Column Assembly. Now it was time to move on to the main dash assembly. There are two actuators on this vehicle that cannot be changed without first removing the dash … Continue reading “2007 Lincoln Town Car, Dash Removal Part 1”
This 2007 Lincoln Town Car came in with the complaint that sometimes the a/c air would not blow out of the face vent. Instead the air would flow from the defrost and floor vents. Sometimes the air would start flowing from the face vents a few seconds after turning the ignition on but would soon … Continue reading “2007 Lincoln Town Car A/C Does Not Blow Out Vents”
I recently had to remove the dash assembly from a 2007 Lincoln Town Car in order to replace several a/c actuators. I divided the repair into several articles due to the length of material and quantity of images. This part is dedicated to removing the steering column. The battery has already been disconnected. Removing the … Continue reading “2007 Lincoln Town Car Removing The Steering Column”
This 2001 Lincoln Continental came in with the complaint that the speedometer and the tachometer were not working. The mileage displayed dashes instead of digits. There were “Check Traction Control” and “Check Transmission” fault messages. The “Service Engine Soon” light was on and codes P0500, P1502, P1744 and U1039 were stored in the PCM. That … Continue reading “2001 Lincoln Continental, Speedometer and Tach Inop”
This 2004 Lincoln town car came in with a rough run condition and codes P0300 and P0304 stored. the standard repair is new spark plugs, new spark plug boot kits and replace #4 coil assembly. I normally do not post tune up type repairs but I decided to do this one to see if there … Continue reading “2004 Lincoln Town Car, Multiple Misfires P0300 & P0304”
This 2000 Lincoln LS came in with the driver’s rear window down. A quick check found that the motor was working but the telltale noise of crunching plastic and cables told me the regulator cable was broken. To remove the door panel, lift the cover in the bottom of the armrest pull handle. Remove the … Continue reading “2000 Lincoln LS, Rear Window Stuck Down”
This 2006 Lincoln Zephyr came in with the complaint that the right low beam headlight does not work. The owner had already installed a new Xenon or HID bulb assembly. If you merely want to change the bulb there is an access panel in the inner wheel well as shown in the following picture. Since … Continue reading “2006 Lincoln Zephyr Low Beam Headlight Does Not Work”
This 1993 Lincoln Town Car came in with the complaint that the right rear passenger power window stalls when going up. Works fine if you help the motor by lifting on the glass. Pretty cut and dry worn out torque pins in the power window motor. The first step in the repair is to remove … Continue reading “1993 Lincoln Town Removing The Right Rear Power Window Motor”