2007 Lincoln Town Car HVAC Actuator Replacement

Now that the Dash Assembly is out of this 2007 Town Car it is time to start changing actuators. The image below is of the backside of the dash assembly. In the very center of the picture is the mode housing. If you look to the right edge you should notice a white round piece … Continue reading “2007 Lincoln Town Car HVAC Actuator Replacement”

2007 Lincoln Town Car Dash Removal Part 2

Now that the Steering Column has been removed and Part One of The Dash Removal has been completed the focus can be turned to the lower connection points. The rocker/kick panel trim cover can be removed by lifting the inner rear edge and shown below. This will release the spring clips that hold it to … Continue reading “2007 Lincoln Town Car Dash Removal Part 2”

2007 Lincoln Town Car, Dash Removal Part 1

Time to remove the dash assembly from this 2007 Lincoln Town Car. I had previously diagnosed a faulty Panel/Defrost Mode Actuator and removed the Steering Column Assembly. Now it was time to move on to the main dash assembly. There are two actuators on this vehicle that cannot be changed without first removing the dash … Continue reading “2007 Lincoln Town Car, Dash Removal Part 1”

2007 Lincoln Town Car A/C Does Not Blow Out Vents

This 2007 Lincoln Town Car came in with the complaint that sometimes the a/c air would not blow out of the face vent. Instead the air would flow from the defrost and floor vents. Sometimes the air would start flowing from the face vents a few seconds after turning the ignition on but would soon … Continue reading “2007 Lincoln Town Car A/C Does Not Blow Out Vents”

2008 Mercury Grand Marquis, A/C Stuck On Heat

This 2008 Mercury Grand Marquis came in with the complaint that the a/c temperature was stuck on full heat. The complaint could have easily been reversed with no heat present and the system stuck on full cold. It has Automatic Temperature Control (ATC). I used my scan tool and found that there was a code … Continue reading “2008 Mercury Grand Marquis, A/C Stuck On Heat”

2009 Mercury Grand Maquis, Air Will Not Blow Out Of Face Vents

This 2009 Mercury Grand Marquis came in with the complaint the air conditioner would only blow air through the defroster vents. Rarely would air come out of the face vents. This is a common problem and can be expensive to repair. A work around, of sorts, is to manually drop the blower speed to the … Continue reading “2009 Mercury Grand Maquis, Air Will Not Blow Out Of Face Vents”

2000 Ford Taurus, A/C Not Working, Fuse #28 / #128 Blows

This 2000 Ford Taurus came in with the complaint that the a/c did not work. The customer had already figured out that the 15 amp fuse number 28 in the underhood fuse box was blown. It is worth noting that in the wiring diagrams that fuse is referred to as fuse number 128. Power on … Continue reading “2000 Ford Taurus, A/C Not Working, Fuse #28 / #128 Blows”

2002 Mercury Grand Marquis, Blower Inop

This 2002 Mercury Grand Marquis came in with a customer complaint of a blower motor that no longer worked. The customer also stated that up until this point it would work sometimes and sometimes not. This repair is also for Crown Victoria and Town Car applications. I guess I have gotten so used to this … Continue reading “2002 Mercury Grand Marquis, Blower Inop”

2000 Ford Taurus, A/C Not Cold

This 2000 Ford Taurus came in with the complaint that the compressor was coming on but the air out of the vents was not cold. In fact it was hot. I checked and the compressor indeed was coming on and the lines were quite cold so I knew the problem was with the blend air … Continue reading “2000 Ford Taurus, A/C Not Cold”